Day: 11 February 2025

If you have geared motors running important and/or critical plant on your site please check your oil levels. Low oil levels and lack of maintenance can mean an expensive replacement is required.

We where asked to investigate issues with this Flygt sewage pump which had stopped working. A test with the meter showed the unit had an earth fault. It was also seriously blocked with a rag and whatever else this used to be !!Please be mindful of what you put down the toilet !! This will […]

Deal Pier stretches 313 meters out in to the English channel. Situated at the end of the Pier is a lovely little Restaurant (highly recommended) with toilet facilities (hence the reason for our visit!) Underneath the restaurant there is a very small building which houses 2 Mono pumps. These are responsible for pumping waste water […]

This Weir pump came to us from one of the water authorities. Extensively corroded, it proved to be a bit of a challenge to get apart. Once it had been dismantled and all of the components shot blasted, we could see what needed doing.Some machining to the seal housings and a new extension shaft (made […]

2 pumps, 1 duty and the other standby.One of these Grundfos pumps had failed previously leaving the standby to take up the slack.This is all well and good until the standby fails as well! These particular pumps are part of a chiller which was now out of service.The pumps where removed, completely overhauled (stator rewound, […]